Supermarket Fuel Water Tube Boiler Price

SZL horizontal bagasse fired supermarket fuel water tube boiler price in Jawa Timur

DZL horizontal bagasse fired boiler in Jawa Timur

Rated evaporation, refers supermarket fuel water tube boiler price fuel species design, and operation at the design parameters, i.e. at a predetermined quality of steam (pressure, temperature) and a certain thermal efficiency, long-term continuous operation, the amount of steam produced per hour . The new boiler at the factory, the amount of evaporation on the nameplate marked, refers to the rated boiler evaporation of this.

5, pressure: uniform vertical force acting on the object surface, called the pressure, in units of "Newton (N)", is represented by the last kgf (kgf). 1 kg = 9.81 Newtons force. Vertical uniformly acting on the pressure per unit area of ​​the object, called the pressure, in units of megapascals (MPa). On the habits, often referred to as the pressure of the pressure, so the pressure mentioned in this book, in fact, should be pressure.

Prevention of industrial supermarket fuel water tube boiler prices produce condensate hazardous industrial boilers which produce condensed water hazard control measures which 1, bold and hydrophobic visible drainage pipe in the boiler inspection process and found that the condensate is not easy to accumulate in the water-tube boiler, while the horizontal boiler shell boiler drain more, but part of the boiler there is still a large amount of condensate (most of which are newly installed and running). The analysis revealed that, due to the large side of the boiler combustion space, even drainage arrangement, large diameter, tube bundle boiler convective condensation water formed can be discharged. Small smoke tube boiler combustion space levels, due to the structure until the drain can only be arranged at the bottom tube sheet boiler and after the drain of less than 30 mm in diameter, and designed to prevent leakage of boiler flue gas, directly connected to the drain pipe drainage pipes. In operation, the contents of the boiler easy to plug welding slag, rust particles. 2, to adjust the position of the economizer due to the large volume of the boiler, economizer boiler mostly installed in a horizontal tail position, while some horizontal boiler economizer housing is mounted directly or obliquely above the boiler flue outlet, the boiler the lowest point of the flue gas flow. Although the drain pipe installed at the bottom of the economizer, but due to gravity, most of the condenser, condenser and condenser will be returned to the boiler flue. During operation, condensed water after a long period of rinsing, immersed in a heating boiler section. Due to the different materials and material economizer boiler, economizer 09CrCuSb, designed using a material having a strong corrosion resistance, and without considering the design of boiler condensate corrosion conditions, 20g materials, poor corrosion resistance, easily corroded. 3, appropriately increasing the return water temperature in the boiler load or the energy efficiency of the testing process in industrial boilers, most of the boiler has a low load operation. Operated at the design load, the exhaust gas temperature before entering the boiler flue gas economizer is higher than the dew point, in the low load operation, the exhaust gas temperature of the boiler flue gas is lower than the dew point, so in the case of satisfying the condition, as far as possible should be boiler work in the vicinity of the design load, or take action. Measures could be taken to improve the return water temperature of the hot water boiler. For example, in the secondary heating system network, a network should decrease the flow, to increase the temperature of the primary water supply and return pipe network. Thereby raising the temperature of the flue gas leaving the boiler heating surface of the body, to avoid condensation of water vapor in the heating surface of the boiler body. 4, the depth of the condensed water recovered by previously described, the industrial gas boiler condensate is quite large, which is part of the condensed water is not effectively contain some depth using heat, in order to take effective measures to recover heat and water. For example, we may be adjusted by adding an alkaline agent (ammonia, cyclohexane, etc.) pH value of the condensate, which is then pumped into the heating system, which not only saves water, and heat is recovered.

Recently, the Longhai carried out safety campaigns to the supermarket fuel water tube boiler price, the campaigns start from the four directions, whether units in accordance with the boiler 'boiler safety practices "to use the correct boiler conducted a comprehensive inspection.

First, the unit register in a boiler boiler inspection. The use of units to crack down on unauthorized use of untested or failed the inspection of boilers.

Second, the units are equipped with a boiler if the security officer and fireman personnel. Focus on checking whether the use of units as required "special equipment operator assessment rules," the fireman with security personnel and staff to meet the requirements, and whether the person has made fireman fireman card.

Third, in the boiler unit will be the safety management system, emergency plans to check the system; and to convey the importance of this inspection in the boiler unit, raise awareness of security units.

Fourth, strengthen supervision of energy-efficient boilers, boiler and actively promote energy efficiency testing, at present, boiler energy efficiency testing has been completed a total of 112 units.

To date, the Longhai inspection operations were dispatched inspectors 209 passengers, checked boiler unit 136, check the boiler 168 units, eliminate safety hazards at 9, and urge the use of sealed units to enhance the energy efficiency of boilers 21 units.

And with the Commission by letter, and environmental protection departments to further promote the comprehensive upgrade of coal-fired boiler energy saving project, disable the coal-fired boiler 53 units, 34 units scrapped, replaced by raw material boiler fuel and natural gas fuel of a total of 40 units, is out of the city coal-fired boilers to make a positive response.