apakah yang dimaksud water tube boiler

August 21 this year, is located in Tai'an City, Shandong Province People's Government issued the "Tai'an City 2018-- 2020 coal consumption reduction alternative work" (the "Program"), "plan" put forward the goal: by 2020 the city's coal total consumption control in less than 16.85 million tons.

"Plan" indicated, coal and other industries to promote the advanced production capacity instead of backward production capacity, optimize the layout of the coal industry, shutting down and eliminate small coal-fired boilers. Upon completion of the city's 10 tons of steam per hour and cleared of all coal-fired boilers, the city and county levels, no new urban area per hour and 35 tons of steam coal-fired boilers; 65 tons of steam per hour and higher fuel coal boiler completed the transformation of energy-saving and ultra-low emissions, reduce coal pollution, speed up the heating pipe network construction to expand the scope of central heating. Actively expand the consumer market in natural gas, fuel structural adjustment, encourage the development of direct supply of natural gas to large users to promote key industrial enterprises, industrial parks to achieve direct supply of natural gas. By 2020, natural gas consumption in the proportion of energy consumption increased to about 7%.

It is reported that the city will strengthen the clean-up before 2017 and shut down illegal projects, energy regulation and elimination of backward small boilers, small thermal power production, and resolutely prevent their return to work to resume production. And optimizing the layout of the coal industry, in strict accordance with the State-owned power plant deploy clean up illegal construction, and resolutely shut down coal units do not meet behind environmental protection, energy consumption, safety and other requirements. Meanwhile, on the basis of improving industrial enterprises above coal consumption data networking direct reporting system, increase audit statistics and law enforcement, and strengthen the quality of statistical data management, improve the accuracy and timeliness of coal consumption statistics.

Gas-fired apakah yang dimaksud water tube boiler to reduce noise from the source control and control the spread of two-pronged approach.

A noise source

Third, pay attention to cleaning up debris in the water tank

Hot water heating boiler water quality of tap water are relatively clean, but in the long-term use may precipitate some of the debris within the tank, the more debris deposited may damage the pump and block valves. Before using professional hot water boilers have to check if there was time to clean up the results, will be able to better ensure the heating effect, avoid high temperatures inside the boiler pressure is too high a risk in the tank.

Horizontal hot water apakah yang dimaksud water tube boiler are some considerations: Priming accident 1 boiler, steam boiler Priming phenomenon (1) rapid fluctuations in the water table level from top to bottom, the water line blurred. (2) pot of water alkalinity, salinity seriously overweight. (3) with a large amount of water steam, decreased steam quality, superheater outlet steam temperature drops. Occurrence of water hammer (4) the steam pipe, the steam leakage occurs at the flange connections for leaks. 2, the processing Priming boiler (1) reduced combustion, little off main steam valve, to reduce the evaporation boiler, to reduce the load and remain stable. (2) fully open the drain valve on the surface of the drum (continuous blowdown valve) and a lower discharge drum appropriately. At the same time to increase the amount of water to reduce boiler water alkalinity and salinity, and you should pay attention to control the water level of protection. (3) boiler pot-treatment shall be discontinued dosing. (4) open superheater, the steam trap and a sub-cylinder pipe. (5) maintenance of the boiler water level slightly lower than the normal level. (6) notice water treatment personnel to take measures to ensure the supply of qualified demineralized water. Increasing the pot of water sample testing times, until the pot of water before qualified becomes normal operation. (7) before the boiler water is not improved, increasing boiler load is prohibited. After the accident elimination, should be promptly wash water gauge.